卡特故障代碼
燃油溫度傳感器或線路故障|挖掘機維修,挖掘機修理,維修挖掘機,修理挖掘機174-04 174-04 Fuel Temperature short to ground 燃油溫度傳感器或線路故障16 626-05 2417-05 Ether Injection Control Solenoid open/short to +batt
乙醚噴射控制電磁閥或線路故障
626-06 2417-06 Ether Injection Control Solenoid short to ground
乙醚噴射控制電磁閥或線路故障
21 678-03 41-03 8 Volt DC Supply short to +batt
8V直流電源故障
678-04 41-04 8 Volt DC Supply short to ground
8V直流電源故障
620-03 262-03 5 Volt Sensor DC Power Supply short to +batt
5V直流電源故障
1079-03
620-04 262-04 5 Volt Sensor DC Power Supply short to ground
5V直流電源故障
1079-04
24 100-03 100-03 Engine Oil Pressure open/short to +batt
機油壓力傳感器或線路故障
100-04 100-04 Engine Oil Pressure short to ground
機油壓力傳感器或線路故障
100-10 100-10 Engine Oil Pressure abnormal rate of change
機油壓力更新率不正常
25 102-03 102-03 Boost Pressure Sensor short to +batt
增壓壓力傳感器或線路故障
102-04 102-04 Boost Pressure Sensor short to ground
增壓壓力傳感器或線路故障
102-10 102-10 Boost Pressure Sensor abnormal rate of change
增壓壓力更新率不正常
102-03 1785-03 Intake Manifold Pressure Sensor voltage above normal
進氣壓力傳感器電壓高于正常值
102-04 1785-04 Intake Manifold Pressure Sensor voltage below normal
進氣壓力傳感器電壓低于正常值
102-10 1785-10 Intake Manifold Pressure Sensor abnormal rate of change
進氣壓力更新率不正常
26 108-03 274-03 Atmospheric Pressure open/short to +batt
大氣壓力傳感器或線路故障
108-04 274-04 Atmospheric Pressure short to ground
大氣壓力傳感器或線路故障
27 110-03 110-03 Engine Coolant Temperature open/short to +batt
冷卻液溫度傳感器或線路故障
110-04 110-04 Engine Coolant Temperature short to ground
冷卻液溫度傳感器或線路產
28 91-13 91-13 Throttle Position calibration required
油門需要校準
32 91-08 91-08 Throttle Position signal abnormal
油門信號不正常
34 190-08 190-08 Engine Speed signal abnormal
發動機轉速信號不正常
723-08 342-08 Secondary Engine Speed signal abnormal
備用發動機轉速信號不正常
35 190-15 E362 (1) Engine Overspeed Warning
發動機超速報警
190-00 E362 (3) Engine Overspeed Shutdown
發動機超速停機
37 94-03 94-03 Fuel Pressure open/short to +batt
燃油壓力傳感器或線路故障
94-04 94-04 Fuel Pressure short to ground
燃油壓力傳感器或線路故障
38 105-03 172-03 Intake Manifold Air Temp open/short to +batt
進氣溫度傳感器或線路故障
105-04 172-04 Intake Manifold Air Temp short to ground
進氣溫度傳感器或線路故障
42 637-13 261-13 Engine Timing calibration required
發動機正時需校準
46 100-17 E360 (1) Low Engine Oil Pressure Warning
機油壓力低報警
100-18 E360 (2) Low Engine Oil Pressure Derate
機油壓力低降載
100-01 E360 (3) Low Engine Oil Pressure Shutdown
機油壓力低停機
51 168-00 168-00 System Voltage high
系統電壓高
168-01 168-01 System Voltage low
系統電壓低
168-02 168-02 System Voltage intermittent/erratic
系統電壓不正常
56 630-02 268-02 Check Programmable Parameters
發動機參數設置需檢查
58 639-09 247-09 J1939 Data Link communications
J1939數據鏈接故障
61 110-15 E361 (1) High Engine Coolant Temperature Warning
冷卻液溫度高報警
110-16 E361 (2) High Engine Coolant Temperature Derate
冷卻液溫度高降載
110-00 E361 (3) High Engine Coolant Temperature Shutdown
冷卻液溫度高停機
62 111-17 E2143 (1) Low Engine Coolant Level Warning
冷卻液位低報警
111-18 E2143 (2) Low Engine Coolant Level Derate
冷卻液位低降載
111-01 E2143 (3) Low Engine Coolant Level Shutdown
冷卻液位低停機
63 94-15 E096 (1) High Fuel Pressure Warning
燃油壓力高報警
64 1636-15 E539 (1) High Inlet Air Temperature Warning
進氣溫度高報警
1636-00 E539 (3) High Inlet Air Temperature Shutdown
進氣溫度高停機
65 174-15 E363 (1) High Fuel Temperature Warning
燃油溫度高報警
174-16 E363 (2) High Fuel Temperature Derate
燃油溫度高降載
174-00 E363 (3) High Fuel Temperature Shutdown
燃油溫度高停機
67 0441-15 E445 (1) High Auxiliary Temperature Warning
輔助溫度高報警
0441-16 E445 (2) High Auxiliary Temperature Derate
輔助溫度高降載
0441-00 E445 (3) High Auxiliary Temperature Shutdown
輔助溫度高停機
0441-03 1836-03 Auxiliary Temperature Sensor open/short to +batt
輔助溫度傳感器或線路故障
0441-04 1836-04 Auxiliary Temperature Sensor short to ground
輔助溫度傳感器或線路故障
68 1387-15 E443 (1) High Auxiliary Pressure Warning
輔助壓力高報警
1387-16 E443 (2) High Auxiliary Pressure Derate
輔助壓力高降載
1387-00 E443 (3) High Auxiliary Pressure Shutdown
輔助壓力高停機
1387-03 1835-03 Auxiliary Pressure Sensor open/short to +batt
輔助壓力傳感器或線路故障
1387-04 1835-04 Auxiliary Pressure Sensor short to ground
輔助壓力傳感器或線路故障
71 651-05 001-05 Cylinder #1 Injector open circuit
1缸噴油器故障
651-06 001-06 Cylinder #1 Injector short
1缸噴油器故障
72 652-05 002-05 Cylinder #2 Injector open circuit
2缸噴油器故障
652-06 002-06 Cylinder #2 Injector short
2缸噴油器故障
73 653-05 003-05 Cylinder #3 Injector open circuit
3缸噴油器故障
653-06 003-06 Cylinder #3 Injector short
3缸噴油器故障
74 654-05 004-05 Cylinder #4 Injector open circuit
4缸噴油器故障
654-06 004-06 Cylinder #4 Injector short
4缸噴油器故障
75 655-05 005-05 Cylinder #5 Injector open circuit
5缸噴油器故障
655-06 005-06 Cylinder #5 Injector short
5缸噴油器故障
76 656-05 006-05 Cylinder #6 Injector open circuit
6缸噴油器故障
656-06 006-06 Cylinder #6 Injector short
6缸噴油器故障挖掘機技術故障與師傅進行溝通交流，官方網站http://www.gzjsyq.cn修理直撥:0551-64493367 服務專線:13956953738
乙醚噴射控制電磁閥或線路故障
626-06 2417-06 Ether Injection Control Solenoid short to ground
乙醚噴射控制電磁閥或線路故障
21 678-03 41-03 8 Volt DC Supply short to +batt
8V直流電源故障
678-04 41-04 8 Volt DC Supply short to ground
8V直流電源故障
620-03 262-03 5 Volt Sensor DC Power Supply short to +batt
5V直流電源故障
1079-03
620-04 262-04 5 Volt Sensor DC Power Supply short to ground
5V直流電源故障
1079-04
24 100-03 100-03 Engine Oil Pressure open/short to +batt
機油壓力傳感器或線路故障
100-04 100-04 Engine Oil Pressure short to ground
機油壓力傳感器或線路故障
100-10 100-10 Engine Oil Pressure abnormal rate of change
機油壓力更新率不正常
25 102-03 102-03 Boost Pressure Sensor short to +batt
增壓壓力傳感器或線路故障
102-04 102-04 Boost Pressure Sensor short to ground
增壓壓力傳感器或線路故障
102-10 102-10 Boost Pressure Sensor abnormal rate of change
增壓壓力更新率不正常
102-03 1785-03 Intake Manifold Pressure Sensor voltage above normal
進氣壓力傳感器電壓高于正常值
102-04 1785-04 Intake Manifold Pressure Sensor voltage below normal
進氣壓力傳感器電壓低于正常值
102-10 1785-10 Intake Manifold Pressure Sensor abnormal rate of change
進氣壓力更新率不正常
26 108-03 274-03 Atmospheric Pressure open/short to +batt
大氣壓力傳感器或線路故障
108-04 274-04 Atmospheric Pressure short to ground
大氣壓力傳感器或線路故障
27 110-03 110-03 Engine Coolant Temperature open/short to +batt
冷卻液溫度傳感器或線路故障
110-04 110-04 Engine Coolant Temperature short to ground
冷卻液溫度傳感器或線路產
28 91-13 91-13 Throttle Position calibration required
油門需要校準
32 91-08 91-08 Throttle Position signal abnormal
油門信號不正常
34 190-08 190-08 Engine Speed signal abnormal
發動機轉速信號不正常
723-08 342-08 Secondary Engine Speed signal abnormal
備用發動機轉速信號不正常
35 190-15 E362 (1) Engine Overspeed Warning
發動機超速報警
190-00 E362 (3) Engine Overspeed Shutdown
發動機超速停機
37 94-03 94-03 Fuel Pressure open/short to +batt
燃油壓力傳感器或線路故障
94-04 94-04 Fuel Pressure short to ground
燃油壓力傳感器或線路故障
38 105-03 172-03 Intake Manifold Air Temp open/short to +batt
進氣溫度傳感器或線路故障
105-04 172-04 Intake Manifold Air Temp short to ground
進氣溫度傳感器或線路故障
42 637-13 261-13 Engine Timing calibration required
發動機正時需校準
46 100-17 E360 (1) Low Engine Oil Pressure Warning
機油壓力低報警
100-18 E360 (2) Low Engine Oil Pressure Derate
機油壓力低降載
100-01 E360 (3) Low Engine Oil Pressure Shutdown
機油壓力低停機
51 168-00 168-00 System Voltage high
系統電壓高
168-01 168-01 System Voltage low
系統電壓低
168-02 168-02 System Voltage intermittent/erratic
系統電壓不正常
56 630-02 268-02 Check Programmable Parameters
發動機參數設置需檢查
58 639-09 247-09 J1939 Data Link communications
J1939數據鏈接故障
61 110-15 E361 (1) High Engine Coolant Temperature Warning
冷卻液溫度高報警
110-16 E361 (2) High Engine Coolant Temperature Derate
冷卻液溫度高降載
110-00 E361 (3) High Engine Coolant Temperature Shutdown
冷卻液溫度高停機
62 111-17 E2143 (1) Low Engine Coolant Level Warning
冷卻液位低報警
111-18 E2143 (2) Low Engine Coolant Level Derate
冷卻液位低降載
111-01 E2143 (3) Low Engine Coolant Level Shutdown
冷卻液位低停機
63 94-15 E096 (1) High Fuel Pressure Warning
燃油壓力高報警
64 1636-15 E539 (1) High Inlet Air Temperature Warning
進氣溫度高報警
1636-00 E539 (3) High Inlet Air Temperature Shutdown
進氣溫度高停機
65 174-15 E363 (1) High Fuel Temperature Warning
燃油溫度高報警
174-16 E363 (2) High Fuel Temperature Derate
燃油溫度高降載
174-00 E363 (3) High Fuel Temperature Shutdown
燃油溫度高停機
67 0441-15 E445 (1) High Auxiliary Temperature Warning
輔助溫度高報警
0441-16 E445 (2) High Auxiliary Temperature Derate
輔助溫度高降載
0441-00 E445 (3) High Auxiliary Temperature Shutdown
輔助溫度高停機
0441-03 1836-03 Auxiliary Temperature Sensor open/short to +batt
輔助溫度傳感器或線路故障
0441-04 1836-04 Auxiliary Temperature Sensor short to ground
輔助溫度傳感器或線路故障
68 1387-15 E443 (1) High Auxiliary Pressure Warning
輔助壓力高報警
1387-16 E443 (2) High Auxiliary Pressure Derate
輔助壓力高降載
1387-00 E443 (3) High Auxiliary Pressure Shutdown
輔助壓力高停機
1387-03 1835-03 Auxiliary Pressure Sensor open/short to +batt
輔助壓力傳感器或線路故障
1387-04 1835-04 Auxiliary Pressure Sensor short to ground
輔助壓力傳感器或線路故障
71 651-05 001-05 Cylinder #1 Injector open circuit
1缸噴油器故障
651-06 001-06 Cylinder #1 Injector short
1缸噴油器故障
72 652-05 002-05 Cylinder #2 Injector open circuit
2缸噴油器故障
652-06 002-06 Cylinder #2 Injector short
2缸噴油器故障
73 653-05 003-05 Cylinder #3 Injector open circuit
3缸噴油器故障
653-06 003-06 Cylinder #3 Injector short
3缸噴油器故障
74 654-05 004-05 Cylinder #4 Injector open circuit
4缸噴油器故障
654-06 004-06 Cylinder #4 Injector short
4缸噴油器故障
75 655-05 005-05 Cylinder #5 Injector open circuit
5缸噴油器故障
655-06 005-06 Cylinder #5 Injector short
5缸噴油器故障
76 656-05 006-05 Cylinder #6 Injector open circuit
6缸噴油器故障
656-06 006-06 Cylinder #6 Injector short
6缸噴油器故障挖掘機技術故障與師傅進行溝通交流，官方網站http://www.gzjsyq.cn修理直撥:0551-64493367 服務專線:13956953738
